Turbine disk failure is one thing that can down a plane, and you can only reduce the probability so much.
Fan blades and turbine blades can be contained by containment cases if they break off, but turbine disks can't. When a disk breaks, it's an uncontained engine failure. A 20 kg disk fragment flying at Mach 1 goes through everything.
Airframes are have a 30-degree fragment spread cone around every disk stage. Airframes are designed so that no single fragment can destroy all redundant systems at once in this zone (flight controls, fuel lines, and hydraulic systems). Jet fuel cannot be stored in the wings in this zone.
chasil 23 minutes ago [-]
I admit that I glossed over the section on the machining of the oil pipe, but the facility appears to bear most of the blame.
These were pulled and scrapped from the whole A380 fleet.
"Investigators also criticized the culture within the Hucknall facility that manufactured the HP/IP bearing hubs, identifying signs of complacency and widespread procedural non-compliance. A paperwork review showed that the required signatures were missing from 131 out of 138 retrospective concessions issued between 2009 and 2011, and a large number of minor non-conformances had not been properly handled through the normal chain of command."
polishdude20 43 minutes ago [-]
What's a turbine disc?
gumby 42 minutes ago [-]
It’s explained in the article
seemaze 13 minutes ago [-]
This remarkable event, along with the an accessible history of the evolution of precision manufacturing is covered in Simon Winchester's excellent book The Perfectionists[0]. The audiobook is narrated by the author, which is quite enjoyable as well.
Plane design so good it helped avoid casualties? Check
Hum... Ah! Not an american Boeing but a french Airbus. Of course.
The article mentions this story should make everyone a little less afraid of flying.
Sure, as long as its not on a Boeing plane.
CursedSilicon 1 hours ago [-]
One of my favourite memories of flying Qantas when I was younger was the inflight entertainment.
If memory serves, they were celebrating some sort of milestone like "60 years without a fatal accident" or similar. Quite an impressive feat!
I'm unclear if it was directly related. But the Qantas inflight entertainment system on our flight from Sydney to Los Angeles meanwhile contained about 12 seasons of the National Geographic series "Air Crash Investigation" (Mayday: Air Disasters for Americans)
I will admit that show made an 18 hour slog of a flight significantly more enjoyable
adaml_623 3 minutes ago [-]
"Even the airplane itself ultimately survived: after a marathon repair that lasted 535 days and cost $139 million, the A380 Nancy-Bird Walton triumphantly returned to the skies in 2012."
This quote amazes me. My understanding is that Airbus, Qantas, and probably Rolls Royce were willing to spend this much because it meant that the incident was not a "hull loss" and therefore not as bad a hit to reputation and safety statistics. Does anyone know if that's true?
Unbelievably comprehensive coverage from the Aviation Herald on this incident below, the owner of which was sued recently over a report to the point he sadly lost his home of over 40 years:
Qantas is a troubled airline. Once a Qantas aircraft technician even told me that Singapore Airlines have a far superior maintenance schedule for their aircraft.
This person claims that he tells his family to avoid flying on Qantas ( but flies on it himself since he gets free flights)
These days Han airlines ( SIA, Cathay,China Eastern) and Middle Eastern airlines (Emirates,Qatar) are far better than Western Airlines ( American, British, Lufthansa, KLM,Qantas).
tomhow 28 minutes ago [-]
Please don’t post off-topic hearsay like this here. The article isn’t about maintenance, it’s about a manufacturing fault and the incredibly good work by the pilots to avert a colossal aviation disaster. Qantas continues to have an unblemished record of safety. There is always a place for scrutiny of airlines’ maintenance and safety practices, but introducing it out of context and basing entirely on a comment from an unidentified individual is not a helpful contribution to this discussion.
Fan blades and turbine blades can be contained by containment cases if they break off, but turbine disks can't. When a disk breaks, it's an uncontained engine failure. A 20 kg disk fragment flying at Mach 1 goes through everything.
Airframes are have a 30-degree fragment spread cone around every disk stage. Airframes are designed so that no single fragment can destroy all redundant systems at once in this zone (flight controls, fuel lines, and hydraulic systems). Jet fuel cannot be stored in the wings in this zone.
These were pulled and scrapped from the whole A380 fleet.
"Investigators also criticized the culture within the Hucknall facility that manufactured the HP/IP bearing hubs, identifying signs of complacency and widespread procedural non-compliance. A paperwork review showed that the required signatures were missing from 131 out of 138 retrospective concessions issued between 2009 and 2011, and a large number of minor non-conformances had not been properly handled through the normal chain of command."
[0]https://www.harpercollins.com/products/the-perfectionists-si...
Plane landed without casualties? Check
Plane design so good it helped avoid casualties? Check
Hum... Ah! Not an american Boeing but a french Airbus. Of course.
The article mentions this story should make everyone a little less afraid of flying.
Sure, as long as its not on a Boeing plane.
If memory serves, they were celebrating some sort of milestone like "60 years without a fatal accident" or similar. Quite an impressive feat!
I'm unclear if it was directly related. But the Qantas inflight entertainment system on our flight from Sydney to Los Angeles meanwhile contained about 12 seasons of the National Geographic series "Air Crash Investigation" (Mayday: Air Disasters for Americans)
I will admit that show made an 18 hour slog of a flight significantly more enjoyable
This quote amazes me. My understanding is that Airbus, Qantas, and probably Rolls Royce were willing to spend this much because it meant that the incident was not a "hull loss" and therefore not as bad a hit to reputation and safety statistics. Does anyone know if that's true?
Some discussion:
2023 https://news.ycombinator.com/item?id=38586773
https://avherald.com/h?article=43309c6d&opt=0
This person claims that he tells his family to avoid flying on Qantas ( but flies on it himself since he gets free flights)
These days Han airlines ( SIA, Cathay,China Eastern) and Middle Eastern airlines (Emirates,Qatar) are far better than Western Airlines ( American, British, Lufthansa, KLM,Qantas).
https://en.wikipedia.org/wiki/China_Eastern_Airlines_Flight_...
Meanwhile Lufthansa had their last fatal crash in 1993. For British it was in 1976.